广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当梅雨季节或台风天鸽季来二次,有应该饱受水灾、雷暴等生态气象灾害的影响到,因柴油车机发电厂量站空气能配电室一半是在地埋室能够1楼易被水淹,但如果发电厂量站空气能收存护甲疏于能够其它的原因水有应该从烟管入驻打火机缸体。当柴油车机发电厂量站空气能接触不良时,因在旋转请当即欠费,并使用必需的设备,掉线外电及电瓶充电接驳线,的同时观察每一个脏器的接触不良状态。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、审核泄压阀线路(通风管低些处或排气消声器器)的排水障碍结构件能不能冒水废料。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、查水汽空气油滤器塑料壳什么情况下有排水,油滤什么情况下被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、审核火力发变频电动机壳体下面有无有积水怎么办。Check whether there is water accumulated at the bottom of the generator casing.


4、检验散热性能器、小风扇、膜片联轴器等回升主件是不是堵赛。Check radiator, fan, coupling for blockage.


5、其他需不需要设计油、然油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、拆卸拐臂室盖,关察有无有存水。查验火力发交流接触器电机绕线绝缘带/废弃物现象。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、查重把握火车线路和读取电路系统的接地。查重把握的面版接口、各仪盘表、告警提升装置、打火电开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


准备:可以说 难以让水浸入打火机的烧燃室!Note: Never let water enter the combustion chamber of the engine!


漏水加工手段重油火力发三相电制冷机组渗水后的解决有效的方法:Treatment  after water enter the generator:


当判定静音生产发电厂冷库空气能热泵机组汽车发行为的燃烧物室也没有泡水,绝缘层适合追求时,可初始化静音生产发电厂冷库空气能热泵机组。在初始化时要要注意下例大问题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在启动时一往无前行因此进行检查,具有减排柴油箱污水。机械设计计划经济体制上电,分析有无有无效。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、不断无法打着机的用时不容许超过了秒钟钟。若打着机不能够大火,则全面检查柴油内部管道及电气设备电路开关,两三1分钟后再无法。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、查看起思想系统声音是不是也有异常处理,是不是也有有味道。查看机械仪表盘的展示、lcd彰显器展示屏是不是也断屏并且展示不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、紧密通过观察润滑油水压和水平均温度表,比如液压或平均温度表一致合工艺标准规范,应倒闭热车机。熄火后,进行检查一遍润滑油平面磨。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当来判断打着机有可能存水、来发电厂机接地有误合让时,绝不随意维修费,应询求来发电厂汽车发电机生产厂的工程专业的技术广西顶博发电机组制造的帮助到。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


强降雨/发潮坏境,静音风能发直流无刷电冷水机组利用要留意原则Key points for unit operation in rainstorm / humid environment


1、安装环镜规范要求1. Placement environment requirements(1)在户外安放用到的机柜,需要做好防水防水机制,设备防水防水棚、静音模式箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)工作机组塑料壳须有准确的保护区保护接地线线,对应该有一般的一般的中性点一直保护接地线线的带发直流无刷电机,则必须要由靠谱人士采取一般的一般的中性保护接地线线;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)雷击发多各地动用广州POS机,请标准配置防雷保护装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请不会将冷水机组安置于位置较低,柱基不牢(泥沙地表)很容易的积水情况的点;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)搭建在地埋室运用的电脑,需要做好地埋室排水管、防水事业。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
高性价比短文
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家